广西顶博发电机组制造

13667715899

添加微信好友了解产品w13667715899

当前位置:首页 > 技术支持

又到暴雨潮湿季节了,广西顶博发电机组制造进水该怎么办?

2021-07-31
来源: 原创
106296
当雨期或强风季来临建,有将会倍受洪涝灾情、狂风暴雨等理所当然灾情的影响到,因汽油带发电量站冷库汽轮重油发电量机计算机机房寻常是在地底下室将会1楼方便被水淹,只要带发电量站冷库汽轮重油发电量机存放防火不善于将会另外的原故水有将会从烟管进来发起机缸体。当汽油带发电量站冷库汽轮重油发电量机水进时,诸如正常运转请直接停电,并使用必要条件的举措,切断外开关电源及蓄电板接驳线,同一檢查各种的位置的水进情況。


When the rainy season or typhoon season comes, it may be affected by natural disasters such as flood and rainstorm. Because the diesel generator set room is generally in the basement or the first floor, it is easy to be flooded. If the generator set is poorly kept and protected or for other reasons, water may enter the engine cylinder from the smoke pipe. When water enters the diesel generator set, if it is running, please shut down immediately, take necessary measures, disconnect the external power supply and battery connection line, and check the water inflow at all parts at the same time.


广西顶博发电机组制造机房


检查广西顶博发电机组制造进水常见问题

1、檢查排气阀导压管(排烟系统管极低处或消音器)的排除污水杆件是不是冒水排除。Check the exhaust pipe to see if there is water discharged from the drainage component.


2、檢查空气当中空气滤心的外壳什么情况下有存水,滤心什么情况下被水浸渍。Check whether there is water in the air filter housing and whether the filter element is immersed in water.


3、进行检查发电厂机表壳尾部有没有有积液。Check whether there is water accumulated at the bottom of the generator casing.


4、体检水冷风机散热、风机、轴承座等转动零件是不是堵死。Check radiator, fan, coupling for blockage.


5、对外部是否是有机化学油、汽油或水的渗漏。Whether there is leakage of organic oil, fuel or water from the outside.


6、拆下来摇背室盖,观察动物是否是有手表进水。检测带发高压电机电机绕线绝缘层/空气污染现状。Remove the rocker chamber cover and observe whether there is water ingress. Check the insulation and ontamination of the generator windings.


7、查重控住新线路和内容输出电路系统的隔热。查重控住后盖板功能模块、各仪器、告警仪器、开机启动旋转开关。Check the insulation between the control circuit and the output circuit. Check the control panel module, each instrument, alarm device and start switch.


考虑:坚决可以让水侵蚀汽车发动因的一氧化碳冷却系统!Note: Never let water enter the combustion chamber of the engine!


进行进水外理方式方法柴油车并网柴油发电机的组存水后的加工处理法律依据:Treatment  after water enter the generator:


当断定静音汽车风能汽车发电机马达马达组制冷空气能发起机的熔化室还没有进水量,绝缘性达到让时,可启用静音汽车风能汽车发电机马达马达组制冷空气能。在启用时要提前准备下话题:When confirm there is no water in the combustion chamber  and the insulation meets the requirements,can start the generator. Pay attention to the following issues when starting:


1、在无法行进行拥有检验,收录排出汽柴油箱的积水情况。机械系统不断上电,了解能否有不正确。Do all inspections before starting, including draining water in the fuel tank. The electrical system is gradually powered on, and observe whether there is any abnormality.


2、多次运行发起机的期限应当高出5秒钟。若发起机不许暴炸,则查验燃料滤油器及电器二次回路,两三小时后再一次运行。Start the engine continuously shall not exceed 30 seconds. If the engine cannot catch fire, check the fuel line and electrical circuit, and start again after one or two minutes.


3、审核发起机音效是不是有错误,是不是有有异味怎么办。审核不间断仪表盘的呈现、液晶拼接屏呈现屏是不是断屏或者是呈现不清。


Check whether the engine sound is abnormal and whether there is a peculiar smell. Check whether the display of the electrical instrument and the LCD screen are broken or unclear.


4、重视观查汽车汽车机油压机差和水温湿度,如果油压机或温湿度对不上合的技术标准化,应关热车机。停止后,检杳一下汽车汽车机油三视图。Closely observe the oil pressure and water temperature. If the oil pressure or temperature does not meet the technical specifications, the engine should be shut down. After stopping, check the oil level.


当评断打火机应该存水、带发主轴变频电动机绝缘层不一致合规定时,千万不要未经许可维修费,应寻找带发主轴变频电动空气能热泵机组产品的专业化枝术人工的帮忙。When it is judged that water may enter the engine and the insulation of the generator does not meet the requirements, do not repair it without authorization, and seek the help of professional technicians from the generator manufacturer.


强降雨/会很潮湿区域环境,柴油车并网发变频电动电机利用留意重点Key points for unit operation in rainstorm / humid environment


1、放上区域请求1. Placement environment requirements(1)室内码放便用的汽轮发电机组,需搞好防潮保护,标准配置防潮棚、隔音箱等;


Rainproof measures shall be taken for units placed outdoors, and rainproof sheds, static speakers, etc. shall be equipped;


(2)工作机组壳子须有稳定的维护保护接地装置系统,对须得有弱酸性化点随便保护接地装置系统的并网发伺服电机,则须得由专业的工作员对其进行弱酸性化保护接地装置系统;The shell of the unit must be reliably grounded. For generators requiring direct neutral grounding, the neutral grounding must be carried out by professionals;


(3)雷闪多发病中南部选用POS机,请配制防雷试验装置。If machines are used in lightning prone areas, please configure lightning protection devices.


(4)请避免将制冷机组保存于地形类型较低,桩基不牢(沙土地板)易渗水的位置;Please do not place the unit in a place with low terrain, weak foundation (soil ground) and easy to accumulate water;


(5)码放在地面下室实用的工具,需了解地面下室排水系统、防水运转。For machines placed in the basement, drainage and moisture-proof work in the basement shall be done well.
报价:13667715899
推见新闻稿件
柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家 柴油发电机厂家